359101 50 LB. ADD-ON KIT
ASSEMBLY INSTRUCTIONS
Part # 6827301
1
Revision: 3/30/99
TOPBOOM or GUIDE ROD SUPPORT
GUIDEROD
HEAD PLATE
WEIGHTSTACK SHAFT
WEIGHTPLATE
WEIGHTSTACK PIN
WEIGHTSTACK CUSHION
3/4” WASHER
WEIGHTSTACK SPACER
FIGURE 2
STEP 2:
• Remove the WEIGHT STACK SELECTOR PIN from the WEIGHT STACK as shown in FIGURE 2.
• Unthread the CABLE from the WEIGHT STACK SHAFT of the HEAD PLATE as shown in FIGURE 2.
• Remove or loosen the TOPBOOM or GUIDE ROD SUPPORT. (Refer to Home Gym instructions)
• Tilt the GUIDE RODS back and remove the HEAD PLATEASSEMBLY, fifteen WEIGHT PLATES, two WEIGHTSTACK CUSHIONS,
two 3/4” WASHERS, and two WEIGHT STACK SPACERS as shown in FIGURE 1. (NOTE: Please discard the two 3/4” WASHERS,
andthetwoWEIGHTSTACKSPACERS.)
• Unbolt the old WEIGHT STACK SHAFT from the HEAD PLATE. (NOTE: Please discard the oldWEIGHT STACK SHAFT.)
1/2
1/2
1/2
1/2
1/2
1/2
0
1
2
3
4
5
6
3
STEP 4:
• SECURELYassemble the 20 HOLEWEIGHTSTACK SHAFT
(1) to the HEAD PLATE. (NOTE:The bolt hole in the HEAD
PLATE should be on top.)
HEAD PLATE
•
•
Insert the two GUIDE RODS through the two WEIGHT
STACK CUSHIONS into the base as shown in FIGURE 3.
Lubricate the GUIDE RODS with a silicon or teflon
spray that is available at most hardware stores.
GUIDEROD
1
USING EXTREME CARE, slide the five new WEIGHT
PLATES (4) and the previous fifteen WEIGHT PLATES
down over the GUIDE RODS onto the WEIGHT STACK
CUSHIONS. (NOTE: Make sure that the key holes of the
WEIGHT PLATES all face the same way.)
•
Carefully Slide the new HEAD PLATEASSEMBLY down
over the GUIDE RODS onto the weight stack as shown in
FIGURE3.
• Attach the WEIGHT STACK LABELS (3) (#16-20) to the
five WEIGHT PLATES (4) as shown on FIGURE 3.
• Screw the CABLE into the WEIGHT STACK SHAFT of the
HEAD PLATE until the CABLE slightly pulls on the HEAD
PLATE.
• TIGHTEN jam nut securely!
• SECURELYtighten all loose connections.
4
3
WEIGHT
STACK
CUSHION
FIGURE 3
Thank you for purchasing the Parabody 359101 50 LB.ADD-ON KIT. If unsure of properuse of equipment, call your local
LifeFitness distributor or call the Parabody customer service department at (800) 328-9714.
4
|