Belling FS 60 DO DF
INTRODUCTION
Thank you for choosing a British
Gas & Electrical connection
built appliance by Belling.
Please refer to installation instructions
for the Gas & Electrical Safety Regulations
and the Ventilation Requirements.
In your own interest, and that of safety,
it is the law that all gas appliances be
installed by competent persons, who will
ensure that the installation is in accordance
with “The Gas Safety (Installation & Use)
Regulations 1994”, & the “The Gas Safety
We hope that the following information
will help you to familiarise yourself
with the features of the appliance, and
to use it successfully and safely.
Our policy is one of constant development
& improvement. Strict accuracy of
illustrations and specifications is not
guaranteed. Modification to design
and materials may be necessary
subsequent to publication.
This appliance must be installed in
accordance with the regulations in
force, and only in a well ventilated
space. Read the instructions before
installing or using this appliance.
Your new appliance is designed to be
installed flush to base units.
(Installation
&
Use) (Amendment)
Regulations 1996”. Failure to comply
with these Regulations is a criminal offence.
Corgi registered installers undertake to
work to satisfactory standards.
Disconnection of gas and electric
appliances should always be carried
out by competent persons.
Warning: This appliance must be
earthed.
To replace an oven light bulb
Your 1st Year Guarantee
Caution: Switch off the electricity
supply to the cooker at the socket, to
avoid the risk of electric shock.
Wait until the oven is cool, then
remove the shelves.
To fulfil the conditions of your guarantee,
this appliance must be correctly
installed and operated, in accordance
with these instructions, and only be
used for normal domestic purposes.
Please note that the guarantee, and
Service availability, only apply to the
UK and Republic of Ireland.
The oven light is at the rear of the oven
cavity.
Remove the loose oven back - unscrew
the 4 securing screws (one at each cor-
ner).
Please note that the oven light bulb is not
covered by the guarantee. Replacement
bulbs can be ordered from your local
supplier, or bought from a hardware store.
Before using the appliance for
the first time, remove any protective
polythene film and wash the oven
shelves in hot soapy water, to remove
their protective coating of oil. Even so,
when you first turn on the oven or grill
you may notice a smell and some smoke.
2
INTRODUCTION
-Unscrew the lens cover (turn anticlock-
wise). Unscrew the bulb and replace.
Replace lens cover.
window, or more effective ventilation,
for example increasing the level of
mechanical ventilation where present.
Replace oven back.
Environmental Protection
Stability bracket
Glen Dimplex Cooking is committed to
protecting the environment and oper-
ates an Environmental Management
System which complies with BS EN
ISO 14001:1996.
If the cooker is to be fitted with a
flexible inlet connection, a stability
bracket should also be fitted to engage
in the back of the cooker. Make sure
this is re-engaged whenever you move
the cooker for cleaning.
Disposal of packaging
•
•
All our packaging materials are
recyclable and environmentally
friendly.
Please help us to protect our
environment by disposing of all
packaging in an environmentally
friendly manner.
If the ignition fails:
•
Check there is a spark when the
ignition button is depressed. If
there is no spark, check that the
electricity supply is switched on at
the cooker control box.
•
Check that the gas supply is
switched on.
•
Please contact your local authority
for the nearest recycling centre.
Caution: Packaging materials can
pose a risk of suffocation - keep away
from children.
Moving the cooker
Do not attempt to move the cooker by
pulling on the doors or handles. Open
the door and grasp the frame of the
cooker, taking care that the door does
not shut on your fingers.
Take care to avoid damage to soft or
uneven floor coverings when moving
the appliance. Some cushioned vinyl
floor coverings may not be designed
to withstand sliding appliances without
marking or damage.
Ventilation
The use of a gas cooking appliance
results in the production of heat and
moisture in the room in which it is
installed. Ensure that the kitchen is well
ventilated: keep natural ventilation
holes open or install a mechanical
ventilation device (mechanical extractor
hood). Prolonged intensive use of the
appliance may call for additional
ventilation, for example, opening of a
3
BE SAFE - NOT SORRY
When you are cooking, keep
children away from the vicinity
of the appliance.
•
Do not use aluminium foil to cover
the grill pan, or put items wrapped
in foil under the grill as this creates
a fire hazard. The high reflectivity
can also damage the element.
Do not use the oven with the door
inner glass panel removed (glass
oven doors only).
Use oven gloves when removing
hot food / dishes from the oven or
grill. The oven / grill and utensils
will be very hot when in use.
Do not use foil on oven shelves, or
allow it to block the oven flue, as
this creates a fire hazard, and
prevents heat circulation.
This product is designed as a domestic
cooking appliance for the preparation
and cooking of domestic food
products, and should not be used for
any other purpose.
•
•
•
•
•
•
•
Remove all packaging, protective
films and oils from the appliance
before using for the first time.
Make sure you read and
understand the instructions before
using the appliance.
Keep electrical leads short so they
do not drape over the appliance
or the edge of the worktop.
Keep all flammable materials (such
as curtains, furnishings & clothing)
away from the appliance.
Parts of the appliance may be hot
during or immediately after use.
Care should be taken to avoid
touching heating elements inside
the oven. Allow sufficient time for
the appliance to cool after
switching off.
•
•
•
When cooking heavy items - eg;
turkeys - do not pull the oven shelf
out with the item still on the shelf.
Switch off the electricity supply
before replacing the oven light bulb,
to avoid the risk of electric shock.
Warning: This appliance must be
earthed.
When you have finished
cooking check that all controls
are in the off position.
•
•
Never use the appliance for
heating a room.
Do not drape tea towels over the
flue vents or doors, as this creates
a fire hazard.
•
When opening the appliance
door, take care to avoid skin
contact with any steam which may
escape from the cooking.
4
USING THE HOB
Ignition
Pans
Push in and turn the selected control
knob anticlockwise to the ‘full on’ position
and press the ignition switch (if fitted),
or hold a lighted match or taper to the
burner, until the burner lights. Turn the
control knob to the required setting.
For optimum safety and performance, we
recommend the use of flat bottomed pans
with a base diameter of minimum 100mm
(4”) and maximum 250mm (10”).
Do not use traditional style double
pans (excluding steamer pans), rim
based pans, old misshapen pans or
any pan which is unstable when
placed on a flat surface.
Adjust the burner flame so that it does
not extend over the pan base.
Position pans over the centre of the
burners, resting on the pan supports.
If positioned off centre, smaller pans
may be unstable.
To turn off, push in the control knob
and turn clockwise until the dot on the
control knob is below the dot on the
facia panel.
When cooking with fat or oil, never
leave unattended.
Turn pan handles to a safe position,
so they are out of reach of children,
not overhanging the appliance, and
cannot be caught accidentally.
Commercial simmering aids should
not be used as they create excessive
temperatures that can damage the
surface and may cause a hazard.
To simmer
The simmer position is marked by the
small flame symbol.
Once lit turn the selected control knob
anticlockwise past the large flame
symbol (FULL ON) to the small flame symbol.
You may hear a slight popping noise
when the hob burners are operating
and this is quite normal, but if anything
about the cooker appears unusual,
such as change in flame appearance,
or the operation of controls - seek
expert advice.
Pan supports
Always make sure the pan supports
are replaced correctly, and located in
the hob spillage well.
5
USING THE HOB
To save gas
The fold down lid
•
Use the size of pan most suited to
Caution: Glass lids may shatter when
heated. Turn off all the burners before
shutting the lid.
When opening and closing the lid, use
the cooler outer sides of the lid trim.
The lid must be opened fully, so there
is no danger of it closing while the hob
is being used.
The appliance is fitted with a switch-
back system, which will automatically
turn off the hotplate controls if they
are inadvertently left on as the lid
is closed.
the size of the burner - ie; larger
pans on the larger burners, smaller
pans on the smaller burners.
Adjust the flames so that they do
not lick up the sides of the pan.
Put lids on saucepans and only heat
the amount of liquid you need.
When liquids boil, reduce the control
setting to maintain a simmer.
•
•
•
•
Consider the use of a pressure
cooker for the cooking of a
complete meal.
The lid is not intended to be used as a
work surface, as it becomes hot when
any part of the cooker is in use, and
the surface may be scratched if items
with rough or sharp surfaces are
placed on it.
•
Potatoes and vegetables will cook
quicker if chopped into smaller
pieces.
Hold the control knob in for 15 sec-
ondsthe release. If the burner fails to
light within this time, release the con-
trol knob and wait one minute before
attempting to re-ignite.
6
USING THE GRILL
Caution: Accessible parts may
the handle to pour hot fats from the
grill pan.
Food for grilling should be positioned
centrally on the trivet.
be hot when the grill is used,
young children should be kept
away.
Detachable grill pan handle
Aluminium foil
Using aluminium foil to cover the grill
pan, or putting items wrapped in foil
under the grill can create a fire hazard,
and the high reflectivity can damage
the grill element.
The cooling fan
When the grill is switched on, you will
hear the cooling fan come on - this
keeps the fascia and control knobs of
the appliance cool during grilling. The
fan may continue to operate for a peri-
od after the grill control has been
switched off.
Place the handle over the edge of the
grill pan, at the narrow side edges.
Slide the handle to the centre, and
locate between the handle position
indicators.
The handle should be removed from
the pan during grilling, to prevent
overheating.
The handle is designed for removing /
inserting the grill pan under the grill
when grilling.
If cleaning the grill pan when it is hot,
use oven gloves to move it. Do not use
7
USING THE GRILL
Using the grill
Important: The door must be kept
open when the grill is used.
To switch off, return the control knob to
the “off” position.
Caution: Accessible parts may
be hot when the grill is used,
young children should be kept
away.
The top oven grill has 3 heat settings
as follows:-
For grilling smaller quantities of food
the centre (economy) grill can be
utilised.
For grilling larger quantities of food,
the full grill can be utilised.
When using the grill in the top oven,
the speed of grilling can be controlled
by adjusting the grill setting or by
selecting a higher or lower shelf posi-
tion.
Full grill area at 1/4
power.
Centre grill area at full
power.
Full grill area at full
power.
For toasting, and for grilling foods
such as bacon, sausages or steaks,
use a higher shelf position.
Preheating
For thicker foods such as chops or
chicken joint pieces, use the low shelf
position.
For best results, preheat the grill for
3 - 5 minutes.
To switch on the grill
Open the top oven / grill door.
Turn the top oven control knob to the
required setting.
8
USING THE TOP OVEN
Accessible parts may be hot
Preheating
when the oven is used. Young
children should be kept away.
The oven must be preheated when
cooking frozen or chilled foods, and
we recommend preheating for yeast
mixtures, batters, soufflés and whisked
sponges.
Preheat the oven until the indicator
light switches off for the first time - this
will take up to 20 minutes depending
on the temperature selected.
If you are not preheating the oven,
the cooking times in the baking guide
may need to be extended, as they are
based on a preheated oven.
To turn on the top oven
Turn the top oven / grill control knob
to the required temperature setting.
The red thermostat indicator (if fitted)
will come on until the selected temper-
ature is reached and then go off; it
will turn on and off periodically as
the thermostat operates to maintain
the selected temperature.
To switch off, return the control knob
to the “off” position.
The cooling fan
When the top oven or grill is switched
on, you will hear the cooling fan come
on - this keeps the fascia and control
knobs of the appliance cool during
cooking or grilling only.
The fan will continue to operate for a
period after the oven control has been
switched off.
Notes:
As part of the cooking process, hot air
is expelled through a vent at the top of
the oven(s). When opening the oven
door, care should be taken to avoid
any possible contact with potentially
hot air, since this may cause discom-
fort to people with sensitive skin. We
recommend that you hold the under-
neath of the oven door handle.
Important: Never put items directly
on the base of the oven with foil, as this
may cause the element to overheat.
Always position items on the shelf.
Should any fault occur with the cooling
fan, the appliance will need to be
serviced - contact Customer Care.
Caution: The top element gets
extremely hot when in use, so take
extra care to avoid touching it.
9
USING THE TOP OVEN
Top oven baking guide
Cooking temperatures
The temperature settings and times
given in the Baking Guides are based
on dishes made with block margarine.
If soft tub margarine is used, it may be
necessary to reduce the temperature
setting. If a recipe gives a different
temperature setting to that shown in
the guide, the recipe instruction should
be followed.
Cooking times
These times are based on cooking in a
preheated oven.
These cooking times are approximate,
because the size and type of cooking
dish will influence time as will personal
preferences.
Shelf positions
Because the top oven is more
compact, it may be necessary to
reduce cooking temperatures specified
in recipes by up to 20˚C.
Use the baking guide as a reference
for determining which temperatures
to use.
As a general guide, when cooking
frozen or chilled food, use the highest
possible shelf position, while allowing
some clearance between the food and
the top element. Follow the instructions
given on packaging.
Item
Temperature
˚C
Shelf
position
Approximate
cooking time
Small cakes
180
160
1
1
15 - 20 mins
20 - 25 mins
Victoria sandwich
(2 x 180mm / 7”)
Swiss roll
Semi rich fruit cake
(180mm x 7”)
Scones
200
140
1
1
8 - 12 mins
1
3
2 ⁄
4
- 2 ⁄ hours
4
215
90 - 100
1
1
10 - 15 mins
2 - 3 hours
Meringues
Shortcrust pastry
Puff / flaky pastry
Choux pastry
200 - 210
200 - 210
200 - 210
1
1
1
Depends on size &
type of cooking dish
& also the filling
Biscuits
Sponge pudding
Milk pudding
160 - 200
150
140
2
1
1
10 - 20 mins
30 - 45 mins
1
2 - 2 ⁄
2
hours
10
Using the Main Oven
Accessible parts may be hot
Preheating
when the oven is used. Young
children should be kept away.
When cooking sensitive items such as
souffle and Yorkshire puddings or,
when cooking bread, we recommend
that the oven is pre-heated until the
neon switches off for the first time. For
any other types of cooking, a pre-heat
is not required.
To switch on the oven
Turn the oven control knob to the
required setting.
The red thermostat indicator will come
on until the selected temperature is
reached and then go off; it will turn on
and off periodically as the thermostat
operates to maintain the selected
temperature.
The cooling fan
The cooling fan may operate when the
main oven is on and may continue to
operate for a period after the oven has
been switched off.
To switch off, return the control knob to
the “off” position.
When using the oven
As part of the cooking process, hot air
is expelled through a vent at the rear
of the oven. When opening the oven
door, care should be taken to avoid
any possible contact with potentially hot
air, since this may cause discomfort to
people with sensitive skin. We recommend
that you hold the underneath of the
oven door handle.
11
Using the Main Oven
Oven furniture
Oven shelves
Slow cooking (
Setting)
I
Make sure that frozen foods are
thoroughly THAWED before cooking.
The oven shelf must be positioned with
the upstand at the rear of the oven and
facing upwards.
Position baking trays and roasting tins
on the middle of the shelves, and leave
one clear shelf position between
shelves, to allow for circulation of heat.
I
Do not slow cook joints of meat or
1
poultry weighing more than 2 ⁄4kg
1
/ 4 ⁄2lb.
I
Preheat the oven to 170˚C and
cook for 30 minutes, then adjust
the oven
control to
(slow
cook setting) for the remainder of
the cooking time.
Slow cooking times will be about
3 times as long as conventional
cooking times.
Do not open the oven door unnec-
essarily during slow cooking, as
this will result in heat loss at low
temperatures.
Always use dishes with tightly
fitting lids. To rectify badly fitting
lids, place foil over the dish
underneath the lid.
Baking tray and roasting tins
I
I
For best cooked results and even
browning, the maximum size baking
trays and roasting tins that should be
used are as follows;
Baking tray
350mm x 280mm
This size of baking tray will hold up to
16 small cakes.
I
Roasting tin
370mm x 320mm
We recommend that you use good
quality cookware. Poor quality trays
and tins may warp when heated,
leading to uneven baking results.
Aluminium foil
Use foil only to cover food or cooking
dishes, using foil to cover the shelves
or oven base creates a fire hazard.
12
Using the Main Oven
Cooking with a fanned oven
Notes:
As this is a high efficiency oven,
you may notice the emission of
steam from the oven when the
door is opened. Please take
care when opening the door.
When 2 or more shelves are being
used, it may be necessary to increase
the cooking time slightly.
Because the 2 oven shelves are wider
than in many ovens, it is possible to
cook 2 items per shelf - eg; 2 victoria
sandwiches or 2 casseroles.
Although you need to keep in mind the
points ‘To help the air circulate freely’
with careful choice of dishes and tins,
it is possible to cook a complete meal,
and perhaps something else for the
freezer, in the oven at the same time.
When roasting meats, you will notice that
fat splashing is reduced, which is due
in part to the lower oven temperatures,
and will help keep cleaning of the
oven to a minimum.
Because a fan oven has an even
temperature throughout the oven, there
is no need to follow the shelf positions
given in the baking guide. There is no
need to interchange dishes onto
different shelves part way through
cooking, as with a conventional oven.
If you are used to cooking with a
conventional oven you will find a
number of differences to cooking with
a fan oven which will require a
different approach:
There are no zones of heat in a fan oven
as the convection fan at the back of
the oven ensures an even temperature
throughout the oven. This makes it
ideal for batch baking - eg; when
planning a party or stocking the
freezer - as all the items will be cooked
within the same length of time.
Foods are cooked at a lower temperature
than a conventional oven, so convention-
al recipe temperature may have to be
reduced. Please refer to the conversion
chart.
Preheating is generally not necessary
as a fan oven warms up quickly.
There is no flavour transference in a
fan oven, which means you can cook
strong smelling foods such as fish at
the same time as mild foods - eg; milk
puddings.
To help the air circulate freely
Position the shelves evenly within the
oven and maintain a clearance from
the oven roof and base.
When batch baking foods that will rise
during cooking - eg; bread - always
ensure that enough space has been
left between the shelves to allow for
the rise.
If more than one cooking dish or
baking tray is to be used on a shelf,
leave
a
gap of at least 25mm
between the items themselves and the
oven interior.
13
Using the Main Oven
Defrosting and cooling in the
Be safe
main oven
Do not defrost stuffed poultry using this
method.
Do not defrost larger joints of meat
and poultry over 2kg / 4lb using this
method.
To defrost frozen foods, turn the
main oven control to the defrost
position, place the food in the centre
of the oven and close the door.
To cool foods after cooking prior to
refrigerating or freezing, turn the
main oven control to the defrost
position and open the door.
Never place uncooked food for
defrosting next to cooked food which
is to be cooled, as this can lead to
cross contamination.
Defrosting meat, poultry, and fish can
be accelerated using this method
but make sure they are completely
thawed before cooking thoroughly.
Place meat and poultry on a trivet in a
meat tin.
Defrosting times
Small or thin pieces of frozen fish or
meat - eg; fish filets, prawns & mince
will take approximately 1 - 2 hours.
Placing the food in a single layer will
reduce the thawing time.
Main oven baking guide
A medium sized casserole or stew will
take approximately 3 - 4 hours.
A 1 ⁄2kg / 3lb oven ready chicken will
take approximately 5 hours, remove
the giblets as soon as possible.
Cooking times & temperatures
1
The temperature settings and times given
in the baking guide are based on dishes
made with block margarine. If soft tub
margarine is used it may be necessary
to reduce the temperature setting.
Allow enough space between shelves
for food that will rise during cooking.
Do not place items on the oven base as
this will prevent air circulating freely.
14
MAIN OVEN CONVERSION GUIDE
Note: this is a high efficiency oven, therefore some adjustment will have to be
made to conventional cooking temperatures. The table below shows convention-
al cooking temperatures, ‘A’ efficiency temperatures and gas marks. For optimum
results, conventional temperatures need to be converted to ‘A’ efficiency tempera-
tures.
For example, an item which would normally cook at a conventional temperature
of 180 ˚C, will now cook at the ‘A’ efficiency temperature of 160˚C.
Conventional temperature ‘A’ Efficiency Oven
Gas Mark
(˚C)
(˚C)
100
110
130
140
150
160
180-190
200
220
230
250
100
110
120
130
140
150
160
170
180
190
200
1/4
1/4
1/2
1
2
3
4-5
6
7
8
9
15
USING THE OVENS
Baking guide
Dish
Recommended
temperature ˚C
Approximate
cooking time
(preheated oven)
Scones
Meringues
180
110
8 - 15
2 - 3hrs
Cakes
Small cakes
Whisked sponge
Swiss roll
Victoria sandwich
(2 x 180mm / 7”)
Genoese sponge
Madeira (180mm / 7”)
Semi rich fruit cake
(205mm /8”)
160
160
170
160
15 - 25mins
15 - 20 mins
10 - 12 mins
20 - 30 mins
160
160
130
20 - 25 mins
1
1hr - 1 ⁄
4
hrs
1
2 ⁄ - 3hrs
2
Christmas cake
(205mm / 8”)
Dundee cake
depending on
recipe
depending on
recipe
1
130
2 ⁄
2
- 3hrs
(205mm / 8”)
Pastry
Flaky / Puff
Shortcrust
Choux
Plate tarts
(2 x 180mm / 7”)
180
170
170
170
depending on
recipe and type
of filling
Biscuits
Shortbread rounds
Nut brownies
Brandy snaps
Flapjacks
160
170
160
160
160
20 - 25 mins
20 - 25 mins
10 - 12 mins
20 - 25 min
10 - 20 mins
Ginger nuts
16
USING THE OVENS
Traditional fruit cakes
Roast turkey
It should be remembered that ovens
can vary over time, therefore cooking
times can vary, making it difficult to be
precise when baking fruit cakes.
It is necessary therefore, to test the
cake before removal from the oven.
Use a fine warmed skewer inserted
into the centre of the cake. If the
skewer comes out clean, then the cake
is cooked.
Roasting turkey involves cooking two
different types of meat - the delicate
light breast meat, which must not be
allowed to dry out, and the darker leg
meat, which takes longer to cook.
The turkey must be roasted long
enough for the legs to cook, so
frequent basting is necessary. The
breast meat can be covered once
browned.
•
Follow the temperatures recommended
in the recipe and then adjust
accordingly to the conversion table
on page 11.
Do not attempt to make Christmas
cakes larger than the oven can
cope with, you should allow at
least 25mm (1 inch) space
between the oven walls and the tin.
•
Always make sure that the turkey
is completely thawed and that the
giblets are removed before cooking.
Turkey should be roasted at
150˚C - 160˚C (fanned) or 150˚C
- 160˚C (conventional) for 20 min-
•
•
utes
per 1lb, plus 20 minutes,
unless packaging advises other-
wise.
•
•
To protect a very rich fruit cake
during cooking, tie 2 layers of
brown paper around the tin.
We recommend that the cake tin is
not stood on layers of brown
paper, as this can hinder effective
circulation of air.
Do not use soft tub margarine for
rich fruit cakes, unless specified in
the recipe.
Always use the correct size and
shape of tin for the recipe quantities.
•
The turkey can be open roasted,
breast side down, for half of the
cook time, and then turned over for
the remainder of the cooking time.
If the turkey is stuffed, add 5
minutes per 1lb to cook time.
If roasting turkey covered with
foil, add 5 minutes per 1lb to
cook time.
•
•
•
•
To test if the turkey is cooked, push a
fine skewer into the thickest part of the
thigh. If the juices run clear, the turkey
is cooked. If the juices are still pink,
the turkey will need longer cooking.
17
USING THE OVENS
Roasting guide
Notes:
The times given in the roasting guide
are only approximate, because the
size and age of the bird will influence
cooking times as will the shape of a
joint and the proportion of the bone.
Frozen meat should be thoroughly
thawed before cooking. For large
joints it is advisable to thaw overnight.
Frozen poultry should be thoroughly
thawed before cooking. The time
required depends on the size of the
bird - eg; a large turkey may take up
to 48 hours to thaw.
Use of a trivet with a roasting tin will
reduce fat splashing and will help to keep
the oven interior clean. Alternatively,
to help reduce fat splashing, potatoes
or other vegetables can be roasted
around the meat / poultry.
•
•
•
When cooking stuffed meat or
poultry calculate the cooking time
from the total weight of the meat
plus the stuffing.
For joints cooked in foil or covered
roasters, and for lidded casseroles,
add 5 minutes per 450g (1lb) to
the calculated cooking time.
Smaller joints weighing less than
1
1.25kg (2 ⁄2lb) may require 5
minutes per 450g (1lb) extra
cooking time.
Position the oven shelf so that the
meat or poultry will be in the
centre of the oven.
•
•
It is recommended that the oven is
cleaned after open roasting.
Cook in oven at:
160C - Main Oven (Fanned)
180˚C - Top Oven (Conventional)
Approximate Cooking Time
(preheated oven)
Beef
Rare
Medium
Well done
20 minutes per 450g (1lb), plus 20 minutes
25 minutes per 450g (1lb), plus 20 minutes
30 minutes per 450g (1lb), plus 30 minutes
Lamb
Medium
Well done
25 minutes per 450g (1lb), plus 25 minutes
30 minutes per 450g (1lb), plus 30 minutes
Pork
35 minutes per 450g (1lb), plus 35 minutes
20 minutes per 450g (1lb), plus 20 minutes
Poultry
18
CLEANING
Caution: Any cleaning agent
Burner caps and heads
used incorrectly may damage
the appliance.
Important: Allow burners to cool
before cleaning.
Always let the cooker cool
before cleaning.
Caution: Hotplate burners can be
damaged by soaking, automatic
dishwashers (or dishwasher powders
Some cooking operations generate
considerable amount of grease, this
combined with spillage can become a
hazard if allowed to accumulate on
the cooker through lack of cleaning.
In extreme cases this may amount to
misuse of the appliance and could
invalidate your guarantee.
It is recommended that the appliance
is cleaned after open roasting.
Do not use caustic pastes, abrasive
cleaning powders, coarse wire wool
or any hard implements, as they will
damage the surfaces.
/
liquids), caustic pastes, hard
implements, coarse wire wool, and
abrasive cleaning pastes.
Clean with a moist soapy pad - eg;
“Brillo”.
For the burners to work safely, the slots
in the burner head where the flames
burn need to be kept clear of deposit.
Clean with a nylon brush, rinse, and
dry thoroughly.
Important: The burner caps and
heads must be repositioned correctly
so that they sit squarely onto the hob
as shown.
All parts of the appliance can be safely
cleaned with a cloth wrung out in hot
soapy water.
Vitreous Enamel parts
GRILL PAN, HOB TOP & PAN SUPPORTS, MAIN
OVEN COMPARTMENT FLOOR, TOP OVEN /
GRILL COMPARTMENT
Use a mild cream cleaner - eg; “Cif”.
Stubborn marks may be removed with
a moistened “Brillo” pad.
The pan supports and grill pan may be
cleaned in a dishwasher, or with a
nylon brush in hot soapy water.
19
CLEANING
Easy care surfaces
Glass parts (if fitted)
MAIN OVEN SIDES AND BACK
GLASS DOOR PANELS, LID GLASS
If you do a lot of open roasting, or
roast at temperatures above 200˚C,
we recommend regular cleaning to
help prevent a build up of fats. Use of
a trivet in a roasting tin when roasting
will help reduce fat splashing.
Do not use abrasives or polishes as
they will scratch and damage the glass.
Use a mild cream cleaner - eg; “Cif”.
Rinse away excess cleaner and dry
with a soft cloth.
Warning: Do not operate the appliance
without the glass panel correctly fitted.
Caution: Most types of cleaning
agent will damage these surfaces.
Important: the inner door glass
panel can be removed for cleaning but
it must be replaced the right way up
(so the reflective side - if fitted - faces
inwards), and pushed fully in to the
stop position. To remove the glass
panel, open the door wide, hold the
top and bottom edges and slide out.
Only use a few drops of washing up
liquid in hot water. Wipe the surfaces
with a clean cloth wrung out in hot soapy
water - if larger splashes of fat do not
readily disappear, scrub the area with
a nylon brush or nylon pan scourer
and hot soapy water. Rinse well and
heat the oven to dry the surfaces.
Chrome plated parts
Painted, plastic and metal finish
parts
OVEN SHELVES & OVEN SHELF RUNNERS,
GRILL PAN TRIVET
OVEN DOOR FRAME & HANDLE, GRILL PAN
HANDLE, FACIA PANEL & CONTROL KNOBS
Do not use abrasives or polishes, use
a moist soap pad - eg; “Brillo”.
Note: Oven shelf runners can be
removed for cleaning. Grasp the
runners, and slide out of the hanging
holes as shown.
Only use a clean cloth wrung out in
hot soapy water.
Note: These items may also be
cleaned in a dishwasher.
Pull out to clean
20
INSTALLATION INSTRUCTIONS
Before you start: Please read the
instructions. Planning your installation will
save you time and effort.
For installation in countries other than the
UK, the appliance must be connected in
accordance with all local gas and electri-
cal regulations.
Prior to installation, ensure that the local
distribution conditions (nature of the gas and
gas pressure) and the adjustment of the
appliance are compatible. The adjustment
conditions are stated on the data badge.
Ventilation Requirements
The room containing the appliance should
have an air supply in accordance with
BS 5440: Part 2: 1989:
This appliance is not connected to a combustion
evacuation device. It shall be installed and
connected in accordance with current
installation regulation. Particular attention
shall be given to the relevant requirements
regarding ventilation.
•
All rooms require an openable window,
or equivalent, and some rooms will
require a permanent vent as well.
3
•
•
For room volumes up to 5m an air
2
vent of 100cm is required.
In your own interest and that of safety, it is
the law that all gas appliances be installed
and serviced by competent persons.
CORGI registered installers undertake to
work to satisfactory standards.
If the room has a door that opens
directly to the outside, or the room
3
exceeds 10m , NO AIR VENT is
required.
3
•
•
For room volumes between 5m and
3
2
Where regulations or standards have been
revised since this handbook was printed,
always use the latest edition.
10m an air vent of 50cm is required.
If there are other fuel burning appliances
in the same room, BS 5440: Part 2:
1989 should be consulted to determine
the air vent requirements.
In the UK the regulations and
standards are as follows:
•
This appliance must not be installed in
a bed sitting room of less than 20m or
3
1. Gas
Safety
Regulations
1996
in a bathroom or shower room.
(Installation and Use).
Windows and permanent vents should
therefore not be blocked or removed without
first consulting a CORGI gas installer.
2. Building Regulations - Issued by the
Department of the Environment.
3. Building
Standards
(Scotland)
(Consolidated) - Issued by the Scottish
Development Department.
4. The current I.E.E. Wiring Regulations.
5. Electricity at Work Regulations 1989.
Failure
to
install
appliances
correctly is dangerous and could
lead to prosecution.
6. BS 6172 Installation of Domestic Gas
cooking Appliances
7. Installation & Servicing Instructions for
this appliance.
21
INSTALLATION INSTRUCTIONS
Whilst every care is taken to eliminate
Clearances
burrs and raw edges from this product,
please take care when handling - we
recommend the use of protective
gloves during installation.
No shelf or overhang or cooker hood
should be closer than a minimum of
650mm, but check with cooker hood
manufacturer’s recommendations.
The cooker must have
clearance above hob level of 90mm
up to a height of 400mm.
a
side
Moving the cooker
Please note that the weight of this
appliance is approximately 60kg
(unpacked).
Take care if the appliance needs to be
lifted during installation - always use
an appropriate method of lifting.
Do not attempt to move the cooker by
pulling on the doors or handles. Open
the door and grasp the frame of the
cooker, taking care that the door does
not shut on your fingers.
Check that there are no projections
in the rear wall which will prevent
the lid (where fitted) being raised to
the vertical position.
This cooker may be fitted flush to
base units. However, for models with
side opening doors, we recommend a
side clearance of 60mm between the
cooker and any side wall.
Take care to avoid damage to soft or
uneven floor coverings when moving
the appliance. Some cushioned vinyl
floor coverings may not be designed
to withstand sliding appliances without
marking or damage.
Clearances & dimensions
Appliance dimensions
All sizes are nominal, and some
variation is to be expected.
The
‘depth’ of the cooker, as given below,
is to the front of the door and
excluding knobs and handles.
This is a type X appliance regarding
installation requirements.
depth:
width:
600mm
600mm
Important: Ensure that you route
all mains cables well clear of any
adjacent heat source.
height (adjustable):
900 - 915mm
height with lid raised: 1430 - 1445mm
22
INSTALLATION INSTRUCTIONS
Stability bracket
4. Fix the bracket to the floor.
Measure from FLOOR LEVEL to
ENGAGEMENT EDGE in the back of
the cooker and add 3mm.
If the cooker is fitted with a flexible
connection, a stability bracket should
be fitted to engage in the back of the
cooker. A stability bracket can be
bought from your local supplier.
5. Assemble the underside of the top
part of the bracket to this height.
A stability bracket can be fitted as
follows:
Levelling
Place a spirit level on a baking sheet
onto an oven shelf.
1. Place the cooker in position and
draw a PENCIL LINE level with the
front edge.
The cooker is fitted with levelling feet
at the front and rear.
2. Mark the centre of the cooker to
give the CENTRE LINE for the bracket.
3. Remove the cooker and mark off
450mm from the PENCIL LINE to
locate the front edge of the lower
bracket.
23
INSTALLATION INSTRUCTIONS
Connect to the electricity supply
Warning: This appliance must be
earthed.
The appliance must be installed by a
competent electrician using a double
pole control unit of 30 ampere minimum
capacity with 3mm minimum contact
separation at all poles.
We recommend that the appliance is
connected by a qualified electrician
who is a member of the N.I.C.E.I.C.
and who will comply with the I.E.E.
and local regulation.
1. Access to the mains terminal is
gained by opening the terminal
block cover at the rear of the
appliance (use a small flat-bladed
screwdriver).
2. Connection should be made with
2
6mm twin and earth cable.
3. First strip the wires, then push the
cable through the cable clamp in
the terminal block cover.
4. Connect the cable to the terminal
block and tighten the cable clamp
screw (see diagram).
5. Close the terminal box, ensuring
that the cover is engaged on the
locking tabs.
24
INSTALLATION INSTRUCTIONS
Connect to the gas supply
Commissioning
1
The inlet to the cooker is
⁄2” BSP
internal situated at the rear right corner.
Burner aeration
Fit the bayonet connection. This should
be located so as to ensure that the
flexible connector hose does not kink.
All burners have fixed aeration and no
adjustment is possible.
Use a 900-1125mm length of flexible
connector.
Pressure setting
G20 Natural Gas @ 20 mbar
Ensure that all pipe work is of the correct
rating for both size and temperature.
Flexible connections should comply
with BS 669. Parts of the appliance
likely to come into contact with a
flexible connector have a temperature
rise of less than 70˚C.
Pressure test point
Use the oven injector
Hob - Turn the control knob to the FULL
ON position, wait a second before
pressing the ignition switch or holding
a lighted match or taper to the burner.
After installation, make sure all
connections are gas sound.
Before leaving the installation
1. Place all the loose parts of the
cooker into position.
2. Show the customer how to operate
the cooker and give them this
handbook. Thank you.
25
TECHNICAL DATA
Data badge
On the bottom of the front frame behind
the oven door.
Electrical supply/Load
220 - 240V ~ 50Hz
3290 - 3915W
Spark generator: Mains operated 6 outlet
controlled by a single rocker switch at the
LHS of the facia to individual electrodes. 2
outlets shorted to earth.
Type of gas
This cooker must only be used with Natural
Gas only, as specified on the appliance
data badge.
Warning: This cooker must be earthed.
Gas category
Natural Gas - I2H
Hob - Burners have burner heads and
caps which are removable for cleaning.
Concealed electrodes to each burner.
Pressure setting
G20 Natural Gas @ 20 mbar
Countries of destination
GB - Great Britain, IE - Ireland
Pressure test point
Use the oven injector
Aeration - Fixed
Fuel
Burner / Element
Nominal
Rate Qn
Injector
Size
Natural
Gas
Hob - LHF
Hob - LHR & RHR
Hob - RHF
1.0kW
2.0kW
3.0kW
8.0kW
77
104
129
-
Total heat input
26
Contact Us
Should you need to get in touch with us (UK and Northern Ireland only), please call
Belling Customer Care Centre Helpline on:
0844 815 3746
For customers outside the UK and Northern Ireland, please contact your local supplier.
When you dial this number you will hear a recorded message and be given a
number of options. This indicates that your call has been accepted and is being
held in a queue. Calls are answered in strict rotation as our Customer Care
Representatives become available.
Enter appliance numbers here for future reference:
Model No
Serial No
Please ensure you have the above details (Model No and Serial No) to hand
when calling Belling Customer Care. They are essential to booking your call.
Glen Dimplex Home Appliances Limited is the owner of the Belling brand and is part of
the Glen Dimplex group of companies.
08 27461 02 © 11.2010
|