O u t d o o r G r i l l i n g P r o d u c t s
PORTABLE ELECTRIC GRILL
MODEL: CEG-980T OWNER’S GUIDE
m You must read this Owner’s Guide m This grill is intended for outdoor household use
only. Do not use indoors or for commenercial
cooking. Fuel, such as charcoal briquettes, is not
before operating your electric grill
This appliance is rated for
• 120volts – 50/60Hz,
• Output: 1500W
• Use only AUONE, type TP-W51-01 temperature-
controlling plug.
to be used with appliance.
The supply cord should be regularly examined for
signs of damage and the appliance is not to be used
if the cord is damaged.
When using electrical appliances, basic safety precautions should always be followed including the following:
Read all instructions
m IMPORTANT SAFEGUARDS
• CAUTION: To ensure continued protection against risk of
electric shock, connect to properly grounded three prong
GFI outlets only. Do not use a two prong adapter
and before cleaning. Allow to cool before handling.
• Do not operate any appliance with a damaged cord or
plug or after the appliance malfunctions or is dropped
or damaged in any manner. Return appliance to the near-
est authorized service facility for examination
repair, or adjustment.
• Read all instructions.
• WARNING: Use only outdoors, do not expose to rain.
This is to prevent electric shock which can cause serious
bodily injury or death.
• Do not let cord hang over edge of table or counter or
touch hot surfaces.
• WARNING: Disconnect appliance from supply circuit
before performing maintenance and cleaning.
• Where applicable, always attach plug to appliance and
check that the control is OFF before plugging cord into
wall outlet. To disconnect, turn the control to OFF, then
remove plug from wall outlet.
• WARNING: For protection against risk of electric shock,
connect to properly grounded outlets only.
• WARNING: For protection against risk of electric shock,
keep extension cord connection dry and off the ground.
• Do not use appliance for other than intended use.
• Avoid contacting moving parts.
• CAUTION: Store Temperature Controller Indoors when
not in use.
• Fuel, such as charcoal briquettes, is not to be used with
appliance.
• Do not clean with metal scouring pads. Pieces can break
off the pad and touch electrical parts, creating a risk of
electric shook.
• To protect against electrical shock do not immerse cord,
plugs, portable appliances in water or liquid.
• Do not use charcoal in this appliance.
• The use of accessory attachments not recommended by
the appliance manufacturer may cause injuries.
• Do not touch surfaces that may be hot. Use handles or
knobs provided.
• Do not place on or near a hot gas or electric burner, or in
a heated oven.
• To protect against electrical shock do not immerse cord,
plugs, protable applicnces (or other specific part or
parts) in water or other liquid.
• Extreme caution must be used when moving an
appliance containing hot oil or other hot liquids.
• Close supervision is necessary when any appliance is
used by or near children.
• USE ONLY AUONE, TYPE TP-W51 TEMPERATURE
CONTROLLING PLUG.
• Make sure appliance is OFF and remove plug from outlet • Household use only.
when not in use, before putting on or taking off parts,
1
SAVE THESE INSTRUCTIONS
Table of Contents
1. Important Safeguards
2. Illustrated Parts List
3. Exploded View
4. Assembly Instructions
5. Warnings
4
5
6
7
9
6. Operating Instructions
7. Cleaning
9
9
8. Storage
10
10
9. Warranty
3
1. IMPORTANT SAFEGUARDSns
2. Illustrated Parts List
DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result
in serious bodily injury or death, or in fire or an explosion causing damage to property.
A.
Lid & Firebox
Cooking Grate
Drip Tray
1 pc
1 pc
1 pc
WARNINGS:
m WARNING: Do not use charcoal or other combustible fuels in this grill. This grill is not designed
for charcoal use and a fire could result. The fire could create an unsafe condition and damage to
the grill.
• Always plug Temperature Controller into grill before • To prevent grill from being splashed or falling into
plugging power cord into outlet.
water, do not set grill within 10 feet of any body of
water such as a pool or pond.
B.
C.
D.
• Do not operate unit if plug receptacle is damaged.
• Operate grill only on a level, stable surface.
• Do not in any way alter this product or its use.
• Do not operate grill with a Temperature Controller
that has a damaged cord or plug. Call The Fulham
Group for a replacement Temperature Controller.
The Temperature Controller is made specifically for
this grill.
• If using an extension cord it must be rated no less
than that of the appliance. Extension cords must be
marked with the letter “W” and with a tag stating,
“Suitable for use with outdoor appliance”.
• Pulling Temperature Controller by the knob could
cause the knob to come off.
• Use shortest length extension cord possible. Do not
connect 2 or more extension cords together.
• Do not allow cord to touch the grill when it is hot.
• This grill is intended for outdoor household use
only. Do not use indoors or for commercial cooking.
• Do not immerse grill or Temperature Controller in
water when cleaning.
• If a flare up occurs, do not use water to put out fire.
Turn grill to OFF. Unplug power cord and wait for
grill to cool.
• Do not leave Temperature Controller in the ON posi-
tion during periods of non-use.
• Do not leave grill unattended when in use.
• Make sure no other high wattage appliances are
plugged into the same circuit when using grill.
Temperature Controller 1 pc
• Keep children and pets away from grill when in use.
• Do not clean this product with a water spray or the
like.
• Young children should be supervised to ensure that
they do not play with the appliance.
• Unplug grill when not in use and cover when cool.
Properly store the appliance indoors when not in
use – out of the reach of children.
• This appliance is not intended for use by young
children or infirm persons unless they have been
adequately supervised by a responsible person to
ensure that they can use the appliance safely.
• Use this grill only as described in this manual. Any
other use not recommended in this manual may
cause fire, electric shock, or injury to persons.
• Clean drip tray regularly.
• Locate power cord away from traffic areas. Arrange
the cord so that it will not be pulled or tripped over.
• Always ensure that electrical socket being used has
the correct rating. Socket must be rated no less
than 120V AC, 13Amps.
• Do not use grill near combustible materials such as
dry grass, shrubs, etc.
• This appliance conforms to technical standards and
the safety requirements for electrical devices.
• Do not allow grill to come into close contact with
flammable materials such as paper, walls, draperies,
towels, chemicals, etc.
• The drip tray must be in place at all times during
grill operation.
• Do not use as a heater.
• Do not build this model of grill in any built-in or
slide-in construction. Ignoring this warning could
cause a fire or an explosion that may damage
property or cause serious bodily injury or death.
• Do not move the grill while it is in use. Allow the
appliance to cool before moving, cleaning or
storing it.
• Do not use grill when raining or snowing.
North American Distributor: The Fulham Group, Newton, MA 02466
4
5
3. Exploded Diagram
4. Assembly Instructions
Remove all the contents from packaging, and make sure
all parts are present before attempting to assemble!
See part list on page 4
Step 1: Extend the grill legs as the shown.
They will click when properly extended
Step 2: Unlock the grill lid by moving the
Lid Lock Handle to the left. Open the lid
and remove the packing materials.
1
2
Lid
12
13
14
15
16
17
18
19
20
21
22
Lid Hinge Pin
Reflector
23
24
25
26
27
28
29
30
31
Drip Tray Left Bracket
Leg Bracket
Lid Handle Base Assy
Lid Handle
3
Control Panel Assembly
Controller Bezel
Lock Knob
Leg Hinge Pin
4
Hook
Spring Lock Assembly
Leg Tube Upper Connector
Leg Tube
5
Lid Inner Panel
Cooking Grate
Upper Lid Hinge
Stopper
6
Temperature Controller
Firebox Assembly
Lock Spring
7
Foot
8
Rubber Foot
9
Heating Element
Lid Cushion
Lock
Probe Guard
10
11
Drip Play Assembly
Drip Tray Right Bracket
Lower Lid Hinge
6
7
5. WARNINGS
Step 3: Put the Drip Tray to the correct position as shown.
• Cover grill or store in weather protected area when not in
use.
m WARNINGS
• Any modification of the appliance may be dangerous.
• Visually inspect cord, plug and Temperature Controller
for damage and wear before operation.
• Clean the grate and cookbox between uses.
– Warning: Do not use the barbecue within 60 cm (24in)
of combustible materials from the back or sides of the
grill. Do not use under any combustible construction.
– Warning: The entire cooking box gets hot when in use.
Do not leave unattended.
– Warning: Keep any electrical power cord away from
any heated surface.
– Warning: Keep the cooking area clear of inflammable
vapors and liquids such as petrol, kerosene, alcohol,
etc., and other combustible materials.
• When heating the grill for the first time, it may give off a
slight burning odor. The grill is burning off excess lubri-
cants found on the heating element. This does not affect
the safety of your grill.
• To prevent fire or electric shock, always use a certified
electrician should new circuits or outlets be required.
• Improperly grouded outlets could cause electrical shock.
• The use of an extension cord is not recommended. If
you must use an extension cord, use the shortest length
extension cord possible. Do not connect 2 or more ex-
tension cords together. Keep connections off the ground
and dry. Do not let cord hang over edge of table top
where it can be tripped over or pulled by children. Only
use extension cord labeled for outdoor use.
– Warning: When cooking, the appliance must be on a
level, stable surface in an area clear of combustible
material.
– Warning: Keep cord clear of cookbox.
6. OPERATING INSTRUCTIONS
7. CLEANING
Step 4: Put the temperature controller into the correct position in the frame
as shown. Ensure it is put in all the way.
Dangers
Cleaning the outside surface:
– Place the grill on a stable, non-combustible surface
– Do not use indoors, or in a recreational vehicle or on a
boat
– Ensure temperature controller is plugged fully into grill
before proceeding
1. Wipe surface grime off with a clean cloth and mild
dishwashing detergent or baking soda.
2. For stubborn surface dirt, use warm soapy water
solution and a nylon scrubbing brush.
3. Clean the rinse with water.
4. Allow surfaces to dry fully before use.
COOkING
1) Open lid
Cleaning the Heating Element:
1. Ensure the grill is unplugged from the power source and
the temperature control unit is removed.
2. Remove the cooking grate.
2) Ensure cooking grate is properly positioned in grill,
and that firebox is free from debris.
3) Preheat grill
3. Remove the heating element by unscrewing the wing
nuts and lifting the element out.
– Turn knob clockwise to MAX. Red light indicates that
power is on.
4. Gently clean the heating element with a damp cloth. Do
not scratch the element’s surface or immerse in water.
5. Reinstall the heating element.
6. Inspect the temperature controller and the power cord
for by any possible damage, and then reinstall.
Any other servicing should be performed by an authorized
service representative.
4) Close lid and allow grill to heat for 5-10 minutes
(longer in clod weather)
5) When beginning to cook, a lower temperature may be
selected by turning knob counterclockwise.
6) When cooking is complete, turn knob counter
clockwise to OFF. Unplug temperature controller.
See storage section for additional requirements.
8
9
8. STORAGE
STORAGE AND/OR NON-USE
• During periods of non-use, the Temperature Controller
with power cord should be in the “OFF” position. Store
grill indoors.
m WARNING: The grill is not intended for installation in
or on recreational vehicles, SUVs and/or boats.
m WARNING: To protect against electrical shock, do not
immerse any part of this appliance in water or any other
liquid.
OPERATING
m WARNING: The grill must not be used upon any
Outside surface – Use a warm soapy water solution to
clean , then rinse with water.
combustible surface such as dry grass, shrubs, etc.
9. WARRANTY and REPLACEMENT PARTS
This warranty covers defects in parts and workmanship for a period of 3 years from the original
purchase date. Any damage claim regarding the enameling must be submitted within 30 days of
purchase to be covered by the warranty.
The following conditions are NOT covered by this warranty:
•
•
•
•
•
•
Unevenness and color variations in the enamel coating.
Damage caused by improper assembly or disregard of the manual.
Use of spare parts not supplied by manufacturer.
Damage resulting from modifications or inappropriate use.
Abuse of the grill
Damage caused by improper maintenance or repairs by an unauthorized person.
Limitations and exclusions:
1.
2.
This warranty applies only to the original purchaser and may not be transferred.
If you can not verify the purchase date of the grill the warranty period will begin on the date the
grill was manufactured.
3.
Replacement or repair parts are warranted for the remaining period of the original part warranty.
Your obligations:
This grill must be assembled, installed, operated and maintained in accordance with all applicable
codes and the instruction manual furnished with this grill. You must keep an invoice, cancelled
check or payment record to verify the purchase date of the grill.
10
11
|