3M Oxygen Equipment 600107046 User Manual

Cartridge 6000 Series

User Instructions for 3M™ Cartridge 6001(07046), 6002,

6003(07047), 6004, 6005, 6006, and 6009

Important: Keep these User Instructions for reference.

For use only with 3M™ 6000 Series, 7000 Series and FF-400 Series half and full facepiece

respirators according to the NIOSH approval label.

07046 and 07047 are catalog numbers only. NIOSH approved as 3M™ 6001 Organic Vapor

Cartridge and 6003 Organic Vapor/Acid Gas Cartridge.

1. These cartridges do not supply oxygen. Do not use in atmospheres containing less than 19.5%

oxygen.

2. Do not use when concentrations of contaminants

- are immediately dangerous to life or health,

- are unknown,

- are greater than 10 times the permissible exposure limit (PEL) with half facepiece

respirators and full facepiece respirators when qualitatively fit tested.

- are greater than 50 times the PEL with full facepiece respirators when quantitatively fit

tested, or

- exceed specific OSHA standards or applicable government regulations, whichever is lower.

3. Do not alter, clean (e.g. vacuum, wash, use compressed air), abuse or misuse these cartridges

and/or respirator.

4. Do not use with beards or other facial hair or other conditions that prevent a good seal between

the face and the sealing surface of the respirator.

Time Use Limitations

Replace cartridge in accordance with an established change schedule or earlier if smell, taste or

irritation from contaminants is detected.

Special Instructions for 3M™ Mercury Vapor or Chlorine Gas Cartridge

6009

3M™ Mercury Vapor Cartridges (6009 and 60929) are equipped with passive 3M™ End of Service

Life Indicators (ESLI). The color change indicator must be readily visible when wearing the

respirator without manipulation. If you cannot readily see the ESLI, do not use. The mercury vapor

cartridges must be discarded when the ESLI changes to the discard color found on the mercury

vapor cartridge label; or within 30 days of opening packaging; or when ESLI becomes dirty or

damaged; or when odors of vapors or gases become noticeable, whichever occurs first. Mercury

vapor has no odor.

NIOSH approval: See NIOSH approval label insert.

FOR MORE INFORMATION

In United States, contact:

Technical Assistance: 1-800-243-4630

For other 3M products:

1-800-3M-HELPS or 1-651-737-6501

3M Occupational Health and

Environmental Safety Division

3M Center, Building 0235-02-W-70

St. Paul, MN 55144-1000

98-0060-0065-1/4