Left Side Panel
Rear Panel
Right Side Panel
Ceramic Refractory
Installation Instructions
for use on Models:
33XDV, 36XDV, 39XDV,
DV360, DVA4136, DVB4136
KT605
Fig. 1 Ceramic Refractory Kit contents.
Finish colors available: Sandstone, Colonial Red, Clas-
sic Black, Silver Gray. Country gray is available for the
DVA4136 and DVB4136 only.
5. Make sure logs are not hot and remove them. Logs
are fragile and easy to break. Handle with care.
Read these instructions before attempting to install
the panels.
6. Remove all the lava rock from the firebox floor.
Save for later.
CAUTION: Before starting installation of
the CR Kit allow unit to cool completely if
it has been in operation.
7. Remove the deflector inside the firebox just behind
the glass. Save the screws.
8. Place the rear panel over the ledge of the rear
log support bracket. You may need to loosen the
screws securing the bracket. Re-tighten the screws
after placing the ceramic panel in place.
Ceramic refractory panels are fragile until
held in place and supported. Handle with
care to avoid damaging or breaking.
Kit contents:
9. Place one of the side panels into place. It will hold
the rear panel secure.
• Left Side Panel (1)
• Right Side Panel (1)
• Rear Panel (1)
10. Place the other side panel into place.
11. Reinstall the deflector using the saved screws.
• Installation Instruction Sheet (not shown) (1)
12. Re-install the lava rock. (Refer to Homeowner’s
Manual)
Installation Instructions
Turn OFF gas and electrical supply to unit before
starting the CR kit installation.
13. Reinstall the logs. (Refer to Homeowner’s Manual)
14. Reinstall the glass frame window and close the
clamps.
1. Check all contents for damage or missing parts.
15. Installation is complete.
2. When the unit is cool, remove top louvre. (Refer to
Homeowner’s Manual)
16. Attach the top louvre (Refer to Homeowner’s
Manual), turn ON the gas supply and electrical sup-
ply, light the unit and close the bottom louvre.
3. Open bottom louvre.
4. Remove the glass frame window. (Refer to Home-
owner’s Manual)
CFM Corporation
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6
10009406 6/07 Rev. 2
|